自動攪拌車一體車出現笨重的原因有哪些？_ 行業動態_新聞資訊_自動攪拌一體車_自動攪拌一體機

站內搜索

新聞資訊

公司新聞行業動態

熱點

自動上料平口攪拌機多種方量可供選擇

2022-12-23

混凝土自動上料攪拌車的功能有哪些？

2022-12-19

混凝土自動拌料車移動式可自行走戶外施工

2022-12-16

自上料攪拌車企業這么多，買車的時候應該看哪方面？

2022-12-12

關于山汽

聯系人：劉老師

電話：400-879-1999

公司：山東山汽工程機械（集團）有限公司

地址：山東省萊州市206國道與308省道交叉口東南50米

自動攪拌車一體車出現笨重的原因有哪些？

所屬分類：行業動態發布時間：2020-07-25 來源：http://www.sooezi.com/ 瀏覽量：0

現在發現有很多的用戶都反應說：現在自己的車子越來越重，為什么會出現這樣的狀況？下面小編就帶來來聊聊出現笨重狀況的方法：

Now it is found that many users have responded and said: now that their cars are getting heavier and heavier, why is this situation? Let's talk about the solution to the heavy situation

作為自動攪拌車一體車這種特殊介質的車輛，如果清洗不到位，很容易出現罐體沾水的情況，下面講一下自動攪拌車一體車平時在使用中的注意事項。

As a special medium vehicle of the automatic mixer truck, if the cleaning is not in place, it is easy to get water on the tank. Here are the precautions in the use of the automatic mixer truck.

預防混凝土沾罐！

Prevent concrete from touching the tank!

一、隨車攜帶一些備用的減水劑

1、 Carry some spare water reducer with you

減水劑是一種能在保持混凝土塌落度不變的情況下，減少拌合用水量，隨車攜帶，能很好地調節混凝土性能的混凝土外加劑。但加減水劑時，一定要記得有混凝土試驗室的人在場，否則混凝土質量不合格，后果將十分嚴重。

Superplasticizer is a kind of concrete admixture which can reduce the amount of water for mixing and carry along with the vehicle under the condition of keeping the slump of concrete unchanged, which can well adjust the performance of concrete. But when adding water reducing agent, we must remember to have the person of concrete laboratory present, otherwise the concrete quality is unqualified, the consequence will be very serious.

二、檢查攪拌罐中的水量

2、 Check the amount of water in the mixing tank

自動攪拌一體車

每一次攪拌車卸貨后返回車內時，應檢查儲水罐內的水量，并保持儲水罐內的水隨時處于滿罐狀態，以備不時之需。

When the mixer truck returns to the truck after unloading, the water volume in the water storage tank shall be checked and the water in the water storage tank shall be kept in the full state at any time for emergency.

三、離站前對混凝土質量的檢查

3、 Inspection of concrete quality before leaving the station

由于原材料的不同，每車混凝土的質量也會有所變化。裝運混凝土離場時，必須注意檢查罐內混凝土的塌落度及易度，注意混凝土的凝固及混凝土的離析沉淀。

Due to different raw materials, the quality of each truck concrete will also change. When the concrete is transported out of the site, attention must be paid to the slump and workability of the concrete in the tank, as well as the solidification of the concrete and the segregation and precipitation of the concrete.

四、盡量減少攪拌車在路上運輸的時間

4、 Try to reduce the transportation time of mixer truck on the road

水泥運輸距離一般在20內，出車前要規劃好行車路線及車輛的運行狀況，限度地減少車輛上路所需時間。

The transportation distance of cement is generally within 20 km. Before driving, it is necessary to plan the driving route and the running condition of vehicles, so as to minimize the time required for vehicles on the road.

五、特殊情況為減少損失先卸料

5、 In special cases, the material should be unloaded to reduce the loss

如遇到特殊原因，造成長時間不能卸料的情況，應隨時查看罐內混凝土情況，一旦發現混凝土攪拌車開始凝固。必須立即進行卸料，以防止整個冷凝罐報廢。

In case of special reasons, if the material can not be unloaded for a long time, the concrete condition in the tank should be checked at any time. Once the concrete mixer truck starts to set. Unloading must be carried out immediately to prevent the whole condensate tank from being scrapped.

本期的精彩內容由自動攪拌一體車的小編整理所得，感謝大家的閱讀，如果有什么不對的地方，歡迎到我們的官網：http://www.sooezi.com，給我們留言評論，我們將會給您一個滿意的答復

Thanks for your reading. If there is anything wrong, please visit our website: http://www.sooezi.com Leave us a comment and we will give you a satisfactory reply

上一頁：自動攪拌一體車罐體容積變小預防的措施有哪些？下一頁：多功能攪拌車到底使用年限是多少？

熱門產品 / HOT PRODUCT