自動攪拌一體車不能轉動的處理方法_ 行業動態_新聞資訊_自動攪拌一體車_自動攪拌一體機

站內搜索

新聞資訊

公司新聞行業動態

熱點

自動上料平口攪拌機多種方量可供選擇

2022-12-23

混凝土自動上料攪拌車的功能有哪些？

2022-12-19

混凝土自動拌料車移動式可自行走戶外施工

2022-12-16

自上料攪拌車企業這么多，買車的時候應該看哪方面？

2022-12-12

關于山汽

聯系人：劉老師

電話：400-879-1999

公司：山東山汽工程機械（集團）有限公司

地址：山東省萊州市206國道與308省道交叉口東南50米

自動攪拌一體車不能轉動的處理方法

所屬分類：行業動態發布時間：2020-06-29 來源：http://www.sooezi.com/ 瀏覽量：0

自動攪拌一體車動力由二類底盤全功率取力器輸出通過傳動軸把動力傳給液壓泵，液壓泵產生液壓能通過油管傳到液壓馬達，液壓馬達把液壓能轉化為動能并通過減速機減速增扭傳遞到攪拌罐。

The power of the automatic mixer truck is output by the full power power take-off of the second type chassis, and the power is transmitted to the hydraulic pump through the transmission shaft. The hydraulic energy generated by the hydraulic pump is transmitted to the hydraulic motor through the oil pipe. The hydraulic motor converts the hydraulic energy into kinetic energy and transmits it to the mixing tank by reducing the speed and increasing the torque of the reducer.

在使用到一定時間之后，過多過少的會出現拌筒不能轉動，一般有3種情況：

After using for a certain period of time, the mixing drum will not rotate if it is too much or too little. Generally, there are three situations:

1、運輸過程中有混泥土卡住了；

1. Concrete stuck during transportation;

2、液壓系統或發動機發生故障；

2. Hydraulic system or engine failure;

3、馬達發生故障。

3. The motor has failed.

應對方法：

Response:

1、運輸過程中有混泥土卡住了；清理干凈就沒有問題了；

1. The concrete is stuck in the process of transportation; there is no problem to clean it up;

2、液壓系統或發動機故障的處理：

2. Handling of hydraulic system or engine failure:

（1）打開攪拌筒檢修孔蓋，旋松馬達上高壓軟管的管接頭，旋轉拌筒使拌筒檢修孔斜向下，將砼從攪拌筒檢修孔排出；

(1) Open the manhole cover of mixing drum, loosen the pipe joint of high-pressure hose on the motor, rotate the mixing drum to make the manhole of mixing drum incline downward, and discharge the concrete from the manhole of mixing drum;

（2）將故障車的高壓膠管從馬達上卸下，把救援用的高壓膠管接上，另一端接在救援車的油泵上，并將應急用的回油管一端接在故障車的馬達泄油口，回油管另一端接在救援車的油泵回油口，利用救援車來控制故障車拌筒的旋轉，將砼排出。

(2) Remove the high-pressure rubber hose of the failure vehicle from the motor, connect the high-pressure hose for rescue, and connect the other end to the oil pump of the rescue vehicle, connect one end of the emergency oil return pipe to the motor oil drain port of the fault vehicle, and connect the other end of the oil return pipe to the oil return port of the oil pump of the rescue vehicle, and use the rescue vehicle to control the rotation of the mixing drum of the failure vehicle and discharge the concrete.

3、馬達發生故障，處理則較簡單，可把救援車的馬達卸下裝在故障車上，再將各個油管接好，啟動救援車即可將拌筒內的砼排出。

3. If the motor fails, the treatment is relatively simple. The motor of the rescue vehicle can be unloaded and installed on the fault vehicle, and then the oil pipes are connected. After starting the rescue vehicle, the concrete in the mixing drum can be discharged.

自動攪拌一體車作為運輸用汽車，在維護和修理方面須遵照交通部的規定，執行“定期檢測、強制維護、視情修理”的維修制度。在這個大前提下，再結合自動攪拌一體車的實際情況，做好維護和修理。在日常維護方面，自動攪拌一體車除應按常規對汽車發動機、底盤等部位進行維護外，還須做好以下維護工作。

As a transportation vehicle, the maintenance and repair of the automatic mixing integrated vehicle shall comply with the regulations of the Ministry of communications, and implement the maintenance system of "regular inspection, compulsory maintenance and repair as the case may be". Under this premise, combined with the actual situation of the automatic mixer, the maintenance and repair should be done well. In terms of daily maintenance, in addition to the routine maintenance of the engine, chassis and other parts of the vehicle, the following maintenance work shall also be done.

上一頁：自動上料攪拌一體車使用不同周期介紹下一頁：自動攪拌一體車在夏季如何降溫？

熱門產品 / HOT PRODUCT